Product ID:D-OX, RUST REMOVER, LIQUID, 9815QT
MSDS Date:06/22/1994
FSC:6850
NIIN:00N060983
MSDS Number: BYDNQ

SYNDYX

5701 S COMPTON AVE
LOS ANGELES, CA 90011
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 800-525-5615

Cage: JO065

SYNDYX

LOS ANGELES, CA 90011 US

Telephone: 800-525-5615

Cage: JO065

PHOSPHORIC ACID (SARA 313) (CERCLA)

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 75%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3;3 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

GLYCOLS, POLYETHYLENE, MONO(NONYL PHENYL) ETHER; (NONIONIC

CAS: 9016-45-9

RTECS: MD0900000

OSHA PEL N/K

ACGIH TLV: N/K

19 G/L.

RTECS: 9999999VO

APPLICABLE REGULATIONS.

RTECS: 9999999ZZ

HANDLE EMPTY CNTNRS AS IF THEY WERE FULL. DO NOT

RTECS: 9999999ZZ

VIOLATION OF FED LAW TO USE THIS PROD IN MANNER

RTECS: 9999999ZZ

MAINTAINED. DO NOT INGEST.

RTECS: 9999999ZZ

CONDITIONS. ENGINEERING OR ADMINISTRATIVE

RTECS: 9999999ZZ

RUBBER, NEOPRENE.

RTECS: 9999999ZZ

& FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

CLOTHING & BOOTS.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CAUSES SEVERE DAMAGE & EVEN
BLINDNESS VERY RAPIDLY. SKIN:CAUSES BURNS, POSSIBLE ULCERATION.
INHAL:MIST OR DUST CAN CAUSE DAMAGE TO NASAL & RESPIRATORY
PASSAGES. INGEST:RESULTS IN SEVERE DAM AGE TO MUCOUS MEMBRANES &
DEEP TISSUES,CAN RESULT IN DEATH ON PENETRATION TO VITAL AREAS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:IMMED FLUSH EXPOS AREA W/WATER FOR AT LST 15 MINS, GET
MED ATTN. REMOVE CONTAM CLTHG. LAUNDER CONTAM CLTHG BEFORE RE-USE.
EYES:IMMED FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS, LIFTING
UPPER & LOWER LIDS OCCAS. GET IMMED MED ATTN. IF MD IS NOT IMMED
AVAIL, CONTINUE FLUSHING W/WATER. INGEST:DO NOT INDUCE VOMIT. VOMIT
WILL CAUSE FURTHER DMG TO THROAT. DILUTE BY GIVING WATER. GIVE
MILK(SUPDAT)

Flash Point Method:COC
Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER FOG, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:ACIDS REACT W/MOST METALS TO RELEASE
HYDROGEN GAS WHICH CAN FORM EXPLOSIVE MIXTURES W/AIR.

Spill Release Procedures:SM SPILL:COVER CONTAM SURF W/SODIUM
BICARBONATE/SODA ASH/SLAKED LIME MIXT (50-50). MIX & ADD WATER IF
NEC TO FORM SLURRY. SCOOP UP SLURRY & WASH SITE W/SODA ASH SOLN. LG
SPILLS:PERS NOT WEARING PROT E QUIP SHOULD BE EXCLUDED FROM AREA OF
SPILL(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL, DRY, WELL-VENTILATED
PLACE AWAY FROM INCOMPAT MATLS. KEEP CNTNR TIGHTLY CLSD WHEN NOT IN
USE. DO NOT USE PRESS TO EMPTY CNTNR.
Other Precautions:DO NOT GET IN EYES, ON SKIN/ON CLTHG. STORE IN
ORIGINAL CNTNRS ONLY AT TEMPS <85F. DO NOT STORE NEAR ACIDS,
OXIDAZBLE MATLS/ORGS. CNTNRS, EVEN THOSE THAT HAVE BEEN EMPTIED,
WILL RETAIN PROD RESIDUE & VAPS. ALWAYS OBEY HAZ WARNINGS & (ING
5)

Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, NIOSH/MSHA APPRVD SUPPLIED RESP IS ADVISED IN ABSENCE
OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA
APPRVD RESPS (NEG P RESS TYPE) UNDER SPECIFIED (ING 8)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:RESISTANT GLOVES SUCH AS NATURAL (ING 9)
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(ING 10)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . TO PVNT SKIN CONTACT, WEAR IMPERVIOUS (ING
11)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC:OF MAGNESIA. KEEP WARM, QUIET. GET MED ATTN IMMED.
INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG DFCLT, ADMIN OXYGEN.
IF BRTHG HAS STOPPED GIVE ARTF RESP. KEEP PERS WARM, QUIET & GET M
ED ATTN. SPILL PROC:UNTIL CLEAN-UP IS COMPLETED. STOP SPILL AT
SOURCE. DIKE TO PVNT SPREADING.

Boiling Pt:B.P. Text:212F,100C
Vapor Pres:5.86
Spec Gravity:1.09
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG ALKALIES, ALKALI METALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIAL: HYDROGEN
CHLORIDE, ACID VAPORS, ETC.

Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS . SM
SPILL:FLUSH DOWN DRAIN W/LG AMTS OF WATER I/A/W APPLIC REGS. LG
SPILLS:COLLECT & ADD SLOWLY TO LG VOL OF AGITATED SOLN OF SODA ASH
& SLAKED LIME. AD D NEUT SOLN TO EXCESS RUNNING WATER I/A/W (ING 4)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.